宇航计测技术 ›› 2021, Vol. 41 ›› Issue (1): 43-47.doi: 10.12060/j.issn.1000-7202.2021.01.08

• 量值传递技术 • 上一篇    下一篇

基于静态累积法的极小气体流量测量研究

冯天佑；成永军；陈联；赵澜；孙冬花；张瑞年   

  1. 兰州空间技术物理研究所，真空技术与物理重点实验室，甘肃兰州 730000
  • 出版日期:2021-02-25 发布日期:2022-03-07
  • 作者简介:冯天佑（1989.08-），男，工程师，硕士，主要研究方向：极小真空流量测量技术。

Research on Measurement of Very Low Gas Flow based on Static Cumulative Method

FENG Tian-you；CHENG Yong-jun；CHEN Lian；ZHAO Lan；SUN Dong-hua；ZHANG Rui-nian   

  1. Science and Technology on Vacuum Technology and Physics Laboratory,Lanzhou Institute of Physics,Lanzhou 730000,China
  • Online:2021-02-25 Published:2022-03-07

PDF (PC)

38

摘要： 通过静态膨胀法与固定流导法获得了(10-9～10-14)Pam3/s的氦标准气体流量，并采用静态累积法对所产生的极小气体流量进行了测量，相应的氦离子流上升率在(10-10～10-15)A/s范围。实验结果表明：气体流量静态累积时的离子流波动随流量降低逐渐增大，降至1.69×10-14Pam3/s时，多个数据点已偏离上升率拟合线较远，此时达到测量下限。在(10-9～7.66×10-12)Pam3/s范围，气体流量与对应离子流上升率有很好的线性，最大偏差为6.8%；当气体流量小于7.66×10-12Pam3/s时，标准流量与离子流上升率的对应关系呈现出明显的非线性。

关键词: 极小气体流量, 静态累积法, 测量下限, 非线性现象

Abstract: He standard gas flow in the range of(10-9~10-14) Pam3/s were obtained by static expansion method and constant conductance method.The generated very low gas flow was measured by static cumulative method where the corresponding He ion current increase rate varied from 10-10 to 10-15 A/s.The experimental results show that the wave motion of the ion current increases with the decrease of gas flow rate.When the flow drops to 1.69×10-14Pam3/s,several data points have deviated from the increase rate fitting line indicating that the lower limit of measurement has been reached.For gas flow rates from 10-9 Pam3/s to 7.66×10-12Pam3/s,their corresponding He ion current rates displayed good consistency with theoretical value,where the maximum deviation from linearity is 6.8%.However,once the flow rate drops below 7.66×10-12Pam3/s,the collected ion current increase rate data clearly diverge from the linear fitting.

Key words: Very low gas flow, Static cumulative method, Lower limit of measurement, Nonlinear phenomena

中图分类号: 

京ICP备09048426号-4　 京公网安备 11010602060144号　版权所有 © 《宇航计测技术》编辑部